Zxr 400 not starting off key

Moderator: Moderators

Post Reply
2wheeledninja
Posts: 10
Joined: Mon Sep 16, 2013 8:55 pm
My Bike: Zxr 400
Location: Exeter,Devon

Zxr 400 not starting off key

Post by 2wheeledninja »

Hi all :)
I've just brought a zxr 400 what a animal !!
When I brought it I was told the regular needed changing so I' have done but now it won't start off the button and every time I press it a clicky noise comes from what sounds like under the seat.
Does anybody know what this could be ?
The bike started off the button when I brought it but now can only be started by bumping it
jimsym
Posts: 93
Joined: Sun Feb 03, 2013 11:39 pm
My Bike: ZXR 400 L9
Location: Hertfordshire

Re: Zxr 400 not starting off key

Post by jimsym »

Have you checked the battery with a multimeter?
User avatar
banner001
Track day God
Track day God
Posts: 2589
Joined: Sat Sep 24, 2011 3:27 pm
My Bike: ZXR400 L4
Location: Nuneaton

Re: Zxr 400 not starting off key

Post by banner001 »

99% likely to be a dead starter motor relay, ebay for a pattern/second hand one, or a kawasaki dealer for an original.
UK ZXR400 L3 (1993) - Fully restored and on the roads, my green beast!
JPN ZXR250 A2 (1990) - Revs to 19,200rpm... 'nuff said :smt003
ross46
Restricted
Restricted
Posts: 825
Joined: Fri Aug 26, 2011 9:31 pm
My Bike: zxr 400 l6

Re: Zxr 400 not starting off key

Post by ross46 »

^+1^ take of the left rear fairing panel, to do this you are going to remove up to 6 bolts (if they're all in there) 1 by the little cross hatch vent bit, 1 by the bottom of the rear seat, 1 under the rider seat, 2 under the pillion seat and one underneath by the rear light, you should then see the starter motor next to the battery (it attaches directly to the battery) and with an insulated screwdriver bridge the two connections (two wires attached by 10mm nuts). If the engine turns over it is the starter motor relay
cargo
zxr400 oc member
zxr400 oc member
Posts: 3341
Joined: Sat Jan 08, 2005 10:33 am
My Bike: tomos moped
Location: Carrickfergus Northern Ireland

Re: Zxr 400 not starting off key

Post by cargo »

it could well be the starter relay/solenoid.............................but I prepared to bet on a dodgy battery 99.99999999999999999999999% certain
2wheeledninja
Posts: 10
Joined: Mon Sep 16, 2013 8:55 pm
My Bike: Zxr 400
Location: Exeter,Devon

Re: Zxr 400 not starting off key

Post by 2wheeledninja »

Thanks for all the replys I'm getting a new battery tomorrow as this one seams to have had it, and I, hoping this will be the fix I'm pretty sure it will be I've spent all day today checking for bad connections, what's the best type of battery to get or is it just standard battery, I can't wait to get it running again so I can take her for a spin :)
Post Reply